OC Condo Framing it back up

OC Condo Photos

Not even half way there. So the Kitchen and baths plus adjoining hallways have all been gutted to the studs and reframed. Most of the electrical had to be replaced and I added finished ceilings to replace the drop ceilings. The worst part were the bathrooms where i had to integrate new framing in with the old. I think i spent more time staring at the structure plotting and replotting what i could do than actually building things out.

Did i mention i tend to over engineer everything as well. Considering this is a 5 story cinderblock structure, all this framing is really non-structural. But who knows what the code really is in OC. In the end my city inspector was very helpful and freely offered his advice. I wasn't doing anything grandiose, just replacing what was already there with very minor modifications.

Learning a lot as I go though. Thankfully I also had Jeff to call for advice as well. Though i'm sure i'll pay for it with sarcastic remarks and family get togethers later on.


Main hall looking towards the entry door, kitchen's on the right and baths to the left



The kitchen with it's new ceiling structure.



Opportunity knocked. There was so much mold in the walls in the hallway i had to rip down the drywall to clean it out. So i decided to switch what was once an owners closet around and make it a pantry since it was right next to the kitchen. To compensate i stole some useless room in the back of one of the bedroom closets to use for a much smaller and more appropriate owners closet.


ie; the new owners closet. Big enough for a vacuum, cleaning supplies and other misc.

Common Bath. The tub has been removed (what a nightmare) and worse was the crappy subfloor they had put in to raise the floor up to accomodate the plumbing for the toilet waste pipe (see the linked photo album). They original plumbing had been set more than 1 inch higher then the slab floor. Therefore even with a 1/2 or 3/4 inch tile floor, the toilet would not be seated on the floor. Pinheads! So they poored a 1 inch concrete subfloor over the slab which i had to break up with the sledge and pneumatic chisel. Even with my respirator, i still coughed up concrete dust for 2 or 3 weeks after.

However, the best part of idiocy came when my plumber and I took a realy good look at the waste pipe and found it used an old school lead flange. Which in the end simply required heating it up with a blow torch and slowly torqueing the flange with a crowbar until the lead softened enough and the flange simple lifted right off. Took about 30 minutes for toilet. Why couldn't they make that adjustment back in 1976?

First bath. Through the studs in the back is the other bath.

Another photo of the kitchen before i got the ceiling hung.

Natalie and Lisa came by with a helping hand a few weekends.

OC Condo Demolition

OC Condo Photos

Good times performing destruction. But behind every wall there's a new discovery. Mold everywhere causes scope creep. So what started out as replacement of fixtures and floors in the Kitchen and BAs turned into an almost complete renovation of both BAs and, Kitchen, Halls and Utility Room.

What have I gotten myself into?

Mold pretty behind most of the cabinets in the kitchen. But the worst was actually in the wall across the hall (not shown). Ended up replacing everything in the kitchen, cabinets, appliances, walls and even put up a drywall ceiling with recessed lights.

I don't think there were any building codes back in the 70s when this place was built. We completely gutted both BAs, which are back to back so you can see both in the photo on the left.

Had to supplement all the framing on these interior walls. A decent challenge since the original stuff was non-standard construction and had to reroute a lot of the wiring and upgrade some plumbing.

Oh, and see those two tubs in the photo on the left, they had to go. But the challenge was that they were both Wrought Iron which requires basing the crap out of them with a 12 lb. sledge spitting shards of porcelain into the air and finally breaking into big chunks. I broke a brand new sledge hammer about 6 swings into demolishing the 2nd tub. It was fun explaining to Home Depot that their product was defective based on what i was trying to accomplish...

All dressed up and a little victory cheer for Mark. And Natalie seems to be a bit leery of the ceiling falling on her head.

Lisa and Natalie gave the tile scraper a go. Thank goodness because at this point of i was about dead and we only had about 5 feet of hallway and the utility room to go.

At this point the place is about 80% gutted. I had to remove do a bit more destruction here and there to make rebuild a bit easier.

And this is just load number one for the dump. Mostly appliances and cabinets. Picture this 10 foot trailer being hauled by my Jeep Wrangler all the way back to Rockville. (I'd looked into using the local OC dump but it was going to require permits and administrative headaches plus $ per ton. Not to mention they would only accept about 2/3rds of the trash. Just easier to take it back to the Shady Grove Transfer Station Rockville.